Product ID:02326 MULTIGEAR LUBE EP SAE 75W
MSDS Date:03/12/1991
FSC:9150
NIIN:01-035-5391
MSDS Number: BKLRJ

Emergency Phone: 914-831-3400 EXT. 204

Info Phone: 914-838-7204

Preparer: MARY JANE VON ALLMEN

Cage: 06668

Telephone: 800-336-5236

Cage: 06668

MINERAL OIL

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 80-95%

LD50 LC50 Mixture:LD50 (ORAL RAT) IS >20 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE IRRITATION TO THE EYES.
BRIEF CONTACT MAY CAUSE SLIGHT IRRITATION. PROLONGED CONTACT MAY
CAUSE SEVERE IRRITATION AND DISCOMFORT, LOCAL REDNESS AND SWELLING.
INHALATION OF VAPORS MAY CAUSE IR RITATION OF THE NOSE AND THROAT,
HEADACHE, NAUSEA, AND DROWSINESS. ABDOMINAL DISCOMFORT, NAUSEA,
DIARRHEA IF INGESTED.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:IRRITATION AND REDNESS OF THE EYES. IRRITATION,
DISCOMFORT WITH LOCAL REDNESS AND SWELLING OF THE SKIN FROM
PROLONGED EXPOSURE. IRRITATION OF THE NOSE AND THROAT WITH
HEADACHE, NAUSEA AND DROWSINESS F ROM INHALATION. ABDOMINAL
DISCOMFORT, NAUSEA AND DIARRHEA FROM INGESTION.
Medical Cond Aggravated by Exposure:BECAUSE OF ITS IRRITATING
PROPERTIES, REPEATED SKIN CONTACT MAY AGGRAVATE AN EXISTING
DERMATITIS (SKIN CONDITION)

First Aid:INHALATION: REMOVE TO FRESH AIR. RESUSCITATE IF NOT
BREATHING. GET MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN: REM OVE CONTAMINATED CLOTHING. WASH WITH SOAP AND
WATER. IF IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION: DO
NOT INDUCE VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET
IMMEDIATE MED. ATTENTION.

Flash Point Method:COC
Flash Point:330F,166C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:VENTILATE AREA. AVOID BREATHING VAPOR. USE
SCBA FOR CONFINED AREAS. CONTAIN SPILL IF POSSIBLE. WIPE UP OR
ABSORB ON SUITABLE MATERIAL AND SHOVEL UP. PREVENT ENTRY INTO
SEWERS AND WATERWAYS.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:MINIMUM FEASIBLE HANDLING TEMPERATURES
SHOULD BE MAINTAINED. PERIODS OF EXPOSURE TO HIGH TEMPERATURES
SHOULD BE MAINTAINED. AVOID WATER CONTAMINATION.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
PROLONGED OR REPEATED BREATHING OF VAPOR. AVOID CONTACT WITH EYES.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Protective Gloves:TO PREVENT CONTACT WITH HANDS.
Eye Protection:SAFETY GOGGLES WITH OPTIONAL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS.

HCC:V6
Spec Gravity:0.8956
Viscosity:33.4 CST@40C
Appearance and Odor:PALE LEMON
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:TOXIC LEVELS OF CARBON MONOXIDE,
CARBON DIOXIDE, IRRITATING ALDEHYDES AND KETONES, AND COMPOUNDS OF
SULFUR.

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.